Lesson learned from COVID-19 pandemic for the future of food industry.

With WHO announcing COVID-19 no longer as a public health emergency of international concern (PHEIC) on May 5, 2023, coupled with the fact that the majority of the countries of the world have dropped strict city lockdown or border closure, this perhaps signals the end of the COVID-19 crisis caused by the SARS-CoV-2 virus. However, the COVID-19 pandemic has resulted in far-reaching effects affecting nearly every aspect of our lives and society. Notably, the food industry including agriculture, food manufacturers, food logistics, distributors and retailers have all felt the profound impact and had experienced significant stress during the pandemic. Therefore, it is essential to retrospect the lessons that can be learned from this pandemic for the food industry. This short review aims to address the food safety issues related to the COVID-19 pandemic by focusing on its foodborne transmission potential, innovations of virus detection strategies suitable for food industry; development of phathogenicaidal methods and devices to inactivate SARS-CoV-2 virus (particularly in industrial scale); and the set-up of related food regulations and guidelines as preventive and control measures for preventing the spread of SARS-CoV-2 virus through the food supply chain during the pandemic. This article may provide useful references for the food industry to minimize the food safety impact of COVID-19 (as well as other respiratory virus) and allows them to better prepare for similar future challenges.

Performance evaluation of a novel adjustable lampshade-type reflector (ALR) in indoor farming practice using choy sum (Brassica rapa var. parachinensis).

The retrieval of lost light energy for promoting vegetable development could be a challenge in indoor farming practice, yet little is attempted so far. In this study, the performance of a novel adjustable lampshade-type reflector (ALR) was investigated to evaluate the feasibility of applying such a device in indoor farm racks (IFR). This application targeted at reflecting stray light back to the IFR for improving the growth and quality of leafy vegetable choy sum (Brassica rapa var. parachinensis). The optimal configuration of ALR was firstly confirmed via simulations using TracePro software. The combination of an included angle at 32° and a reflective board width of 10 cm, under 12 cm of distance between the light sources and the germination tray surface, was revealed to achieve a cost-optimal reflective effect. The simulation-based ALR was subsequently custom-built for actual performance validation. It was shown to effectively produce uniform distributions of temperature, relative humidity, and photosynthetic photon flux density as well as to accumulate more photosynthetic photon energy density along the cultivation shelf. Compared with the control where no ALR was used, the fresh weight and the dry weight of choy sum shoots cultivated using an ALR were increased by up to 14% and 18%, respectively. In addition, their morphological traits were found to be more uniform. Furthermore, their total carotenoid level was enhanced by up to 45%, while the chlorophyll b level was markedly decreased. However, no statistically significant difference was found in total phenolic content and antioxidant capacity across the shelf, indicating that the ALR application led to a more uniform antioxidant-related quality of choy sum shoot. ALR application in IFR can thus effectively boost vegetable production and result in quality improvements under an identical amount of electricity consumption in indoor farming compared with ALR-free control.

Light-Time-Biomass Response Model for Predicting the Growth of Choy Sum (Brassica rapa var. parachinensis) in Soil-Based LED-Constructed Indoor Plant Factory for Efficient Seedling Production.

Little is known about how exactly light plays its role in the growth of choy sum (Brassica rapa var. parachinensis), a widely cultivated vegetable in Asia. By applying a commercial soil using black peat as major constituent with 17:10:14 ratio of NPK fertilizer in this study, the growth responses of choy sum seedling to progressively increasing white LED light intensity in an indoor plant factory were investigated, where positive enhancements were observed in choy sum morphology and growth including both dry and fresh mass accumulation under higher light intensity till 400 µmol/(m2⋅s), then a reduction occurred due to light oversaturation and overheat. In indoor plant factory, the inhomogeneous distribution phenomenon of illumination level was inevitably occurred in indoor farm racks generally. For accurately evaluating the productivity of choy sum grown on such racks, a light-time-biomass response model of choy sum seedling grown at the seedling stage was thus established for the first time, which could reliably predict the production outcome of this species in indoor farming practice under various lighting condition and duration. The robustness of the model was further tested by model variation test and sufficient robustness of this model was confirmed. The new insight obtained for the light-dependence of choy sum growth and the light-time-biomass response model can be used to efficiently direct its seedling production in indoor plant factories.

Cold stress treatment enhances production of metabolites and biodiesel feedstock in Porphyridium cruentum via adjustment of cell membrane fluidity.

Porphyridium cruentum, a cell-wall-free marine Rhodophyta microalga was cultured under a 5-day cold stress at 0 °C and 15 °C, after reaching the late logarithmic growth phase. Compared with the control at 25 °C, the cold stress treatment significantly (p < 0.05) increased the microalgal biomass (1.21-fold); the amounts of total polyunsaturated fatty acids (1.22-fold); individual fatty acids including linoleic acid (1.50-fold) and eicosatrienoic acid (1.85-fold), and a major carotenoid zeaxanthin (1.53-fold). Furthermore, production of biodiesel feedstock including total C16 + C18 fatty acids was significantly enhanced (p < 0.05) by 1.18-fold after the cold stress treatment. Principal component analysis further indicated that the biosynthetic pathways of fatty acids and carotenoids in this microalga were correlated with the cold stress treatment. These results suggested that P. cruentum had adjusted its cellular membrane fluidity via an 'arm-raising and screw-bolt fastening' mechanism mediated by the synergistic roles of cis-unsaturated fatty acids and carotenoids. The insight obtained from the responses to cold stress in P. cruentum could be a novel technological approach to enhance the production of microalgal metabolites and biodiesel feedstock.

Light Intensity Plays Contrasting Roles in Regulating Metabolite Compositions in Choy Sum (Brassica rapa var. parachinensis).

Light intensity can be an efficient tool in regulating leafy vegetable quality and yet little is known mechanistically hitherto. In this study, choy sum metabolic responses to progressively increasing white light intensity were investigated in terms of its essential metabolites including chlorophylls, carotenoids, phenolic compounds, and glucosinolates. Significant enhancements were observed in choy sum's nutritional quality like the total phenolic content and antioxidant capacity under a high intensity of light. However, progoitrin was significantly increased by up to 7.54-fold under a low light intensity of 50 µmol/(m2·s) compared with high light intensity, presenting a unique virus/pest-prevention strategy of choy sum under poor growth status. Pearson's correlation analysis revealed a linear relationship between the light intensity and some metabolites. Principal component analysis further confirmed such contrasting roles of light intensity. The new knowledge gained about light-influenced choy sum metabolite levels can be critical in directing farmers in indoor farming practice for improving vegetable nutritional values.

Cyperenoic acid, a sesquiterpene derivative from Croton crassifolius, inhibits tumor growth through anti-angiogenesis by attenuating VEGFR2 signal pathway in breast cancer.

BACKGROUND: Cyperenoic acid, one of the main chemical constituents of the root of Croton crassifolius, exhibited potent anti-angiogenic property on the zebrafish embryo model with little cytotoxicity. Nevertheless, its anti-angiogenic mechanism and anti-tumor effect have not been investigated. PURPOSE: To investigate the anti-angiogenic mechanisms of cyperenoic acid and evaluate it whether could exert anti-tumor effect by inhibiting angiogenesis. STUDY DESIGN: Targeting vascular endothelial growth factor receptor-2 (VEGFR2) pathway to inhibit tumor angiogenesis is a significant strategy for cancer treatment. Initially, the anti-angiogenic effect of cyperenoic acid as well as the mechanisms of the action was studied using both in-vitro and in-vivo methodologies. Then, its anti-tumor effect through anti-angiogenesis by attenuating VEGFR2 signaling pathway was evaluated. METHODS: The in-vitro inhibitory effect of cyperenoic acid on the vascular endothelial growth factor (VEGF)-induced angiogenesis was evaluated using human umbilical vein endothelial cells (HUVECs) model. Moreover, its ex-vivo and in-vivo effects were evaluated using the aortic ring assay and the matrigel plug assay. The influence of the cyperenoic acid on tyrosine phosphorylation of VEGFR2 was studied by western blotting assay and the influence on downstream signaling pathway of VEGFR2 also be detected. Computer-docking simulations were carried out to study the interaction between cyperenoic acid and VEGFR2. Finally, its inhibitory effect on tumor growth was studied using breast cancer xenograft model. RESULTS: Cyperenoic acid possessed little toxicity to HUVECs, but it significantly inhibited VEGF-induced proliferation, invasion, migration and tube formation of HUVECs. Moreover, it inhibited VEGF-induced sprout formation ex vivo and vessel formation in vivo. Further mechanistic study showed that cyperenoic acid could suppress VEGFR2 tyrosine kinase activity and alter its downstream signaling pathways in VEGF-induced HUVECs. In addition, it could form two hydrogen bonds with the ATP binding pocket of the VEGFR2 kinase domain by docking. For breast cancer xenograft model, cyperenoic acid suppressed tumor growth, but no obvious toxic pathologic changes were observed in mice. Besides, it suppressed the phosphorylation of VEGFR2 in tumor, demonstrating its anti-angiogenic ability in vivo partly targeting the VEGFR2. CONLUSION: Cyperenoic acid could exert anti-tumor effect in breast cancer by inhibiting angiogenesis via VEGFR2 signaling pathway.

Enhancement of the Production of Bioactive Microalgal Metabolites by Ultraviolet Radiation (UVA 365 nm).

Two marine microalgae, Nitzschia closterium and Isochrysis zhangjiangensis, treated for 9 days with photosynthetically active radiation (PAR), were subjected to 3 days of ultraviolet light band A at 365 nm (UVA365) followed by a 3 day post-UVA PAR treatment. Compared with the control that only had PAR treatment, UVA365 treatment significantly ( p < 0.05) increased the amounts of total xanthophylls in N. closterium and I. zhangjiangensis by up to 3.53- and 1.23-fold, respectively, after 3 days of UVA365 irradiation. In particular, UVA365 treatment markedly ( p < 0.05) increased two major bioactive xanthophyll pigments, fucoxanthin in N. closterium and diadinoxanthin in I. zhangjiangensis, by up to 1.97- and 1.52-fold, respectively. UVA365 treatment significantly ( p < 0.05) increased the accumulation of another bioactive microalgal metabolite, total mycosporine-like amino acids, in N. closterium and I. zhangjiangensis by up to 1.40- and 1.30-fold, respectively. UVA365 irradiation has potential as an efficient approach for enhancing the production of valuable microalgal metabolites.

Mechanistic Study of the In Vitro and In Vivo Inhibitory Effects of Protocatechuic Acid and Syringic Acid on VEGF-Induced Angiogenesis.

The antiangiogenic activities of two structurally similar phenolics, protocatechuic acid (PA) and syringic acid (SA), were investigated. In vitro study using HUVECs demonstrated that both PA and SA (at 25 µM) significantly ( p < 0.05) inhibited VEGF-induced cell proliferation by 22.68 ± 5.6% and 21.93 ± 2.0%, respectively; cell migration by 50.04 ± 3.3% and 39.72 ± 4.7%, respectively; cell invasion by 44.16 ± 4.23% and 51.90 ± 2.73%, respectively; and cellular ROS generation by 11.48 ± 6.32% and 21.17 ± 9.10%, respectively. Our mechanistic study revealed that PA and SA blocked the VEGFR2-dependent Akt/ MMP2 and ERK pathways in HUVECs. These inhibitory effects were further confirmed by a decrease of endogenous alkaline phosphatase activity for PA and SA (21.47 ± 1.77% and 10.37 ± 1.27%, respectively) and the suppression of subintestinal vessel plexus formation in Tg (fli1a:EGFP) y1-type transgenic zebrafish embryos. PA and SA down-regulated the angiogenesis-related signal transduction pathway of VEGFα-VEGFR2 or Ang2- Tie2 in zebrafish. Moreover, it was also found that PA demonstrated a better inhibition on VEGF-induced migration of HUVEC and zebrafish vasculature. This might be due to the different number of hydroxyl and methoxy substituents possessed by PA and SA. Taken together, these findings indicate that phenolics PA and SA have potent antiangiogenic activities and are potential targets for the design and development of anticancer agents.

Occurrence and biosynthesis of carotenoids in phytoplankton.

Naturally occurring carotenoids are important sources of antioxidants, anti-cancer compounds and anti-inflammatory agents and there is thus considerable market demand for their pharmaceutical applications. Carotenoids are widely distributed in marine and freshwater organisms including microalgae, phytoplankton, crustaceans and fish, as well as in terrestrial plants and birds. Recently, phytoplankton-derived carotenoids have received much attention due to their abundance, rapid rate of biosynthesis and unique composition. The carotenoids that accumulate in particular phytoplankton phyla are synthesized by specific enzymes and play unique physiological roles. This review focuses on studies related to the occurrence of carotenoids in different phytoplankton phyla and the molecular aspects of their biosynthesis. Recent biotechnological advances in the isolation and characterization of some representative carotenoid synthases in phytoplankton are also discussed.

Two-step cultivation for production of astaxanthin in Chlorella zofingiensis using a patented energy-free rotating floating photobioreactor (RFP).

In the present study, high light and nitrogen starvation with glucose-fed to the culture was found efficient to induce astaxanthin accumulation in Chlorella zofingiensis. Therefore, a two-step cultivation strategy including high biomass yield fermentation and outdoor induction with an energy-free RFP was conducted. During the fermentation, the highest cell density of 98.4gL-1 and astaxanthin yield of 73.3mgL-1 were achieved, which were higher than those so far reported in C. zofingiensis. During the outdoor induction, astaxanthin content was further increased by 1.5-fold leading to the highest astaxanthin productivity of 5.26mgL-1day-1 under an optimal dilution of 5-fold. Our work thus provided an effective two-step cultivation strategy for production of astaxanthin by C. zofingiensis.

Phytochemical profiles of marine phytoplanktons: an evaluation of their in vitro antioxidant and anti-proliferative activities.

Marine microorganisms such as phytoplanktons are a rich resource of bioactive components with antioxidant and anti-proliferative activities that can act as novel functional food ingredients. In this study, the pigment profiles, total mycosporine-like amino acids (MAAs) and total phenolic contents (TPCs) in solvent extracts including 90% acetone and methanol from five marine phytoplanktons including Nitzschia closterium (Bacillariophyta), Isochrysis zhangjiangensis (Haptophyta), Platymonas subcordiformis (Chlorophyta), Porphyridium cruentum (Rhodophyta) and Synechocystis pevalekii (Cyanobacteria) were analyzed. Each phytoplankton from different phyla had its unique compositions of carotenoids and chlorophylls. The 90% acetone extract from I. zhangjiangensis had the highest MAA content (508.30 µg per g DW) while the methanol extract from N. closterium had the highest level of TPCs (6.15 mg GAE per g DW) among all the phytoplanktons investigated. The amounts of total carotenoids in all the 90% acetone extracts from the five phytoplanktons as well as total MAAs in those from within the four microalgae except S. pevalekii were found to be strongly correlated with their antioxidant activities evaluated by the DPPH, TEAC and FRAP assays. Only the level of total carotenoids in the phytoplanktons was correlated with their anti-proliferative activities assessed by the MTT assays using MCF-7 cells. Therefore, individual carotenoid pigments seemed to be mainly responsible for the antioxidant and anti-proliferative (or anticancer) activities found in the solvent extracts of the five phytoplanktons. Hence these phytoplanktons have the potential as novel sources of natural food antioxidants and anticancer agents to be used as active ingredients in functional food products.

An enclosed rotating floating photobioreactor (RFP) powered by flowing water for mass cultivation of photosynthetic microalgae.

BACKGROUND: The design of photobioreactor (PBR) for outdoor mass cultivation of microalgae determines the distribution of solar irradiance among cells in the culture, mode of agitation, mass transfer efficacy, and energy consumption, thus determines the productivity of the system and the cost of production. In this study, the concept of a floating photobioreactor with rotation function is proposed. Dunaliella tertiolecta, a model microalga, cultured in the attached vessels was evaluated. RESULTS: The rotation of the photobioreactor was powered by flowing water, in this case waves generated through a paddle wheel in an outdoor raceway pond for proof of concept. The rotating floating PBR (RFP) could be powered by natural flowing stream, river, and tidal waves, thus there could be no energy cost for agitation of the cultures in maintaining the cells in suspension. This RFP is characterized by its energy-saving and temperature control properties as well as more homogenous light distribution in the culture as compared to conventional culture systems, such as raceway pond. Maximal cell concentration of 8.38 × 106 cells mL-1, biomass productivity of 3.10 g m-2 day-1, and photosynthetic efficiency of 4.61 % (PAR) were achieved. In addition, satisfactory productivities of D. tertiolecta metabolites including carotenoids, mycosporine-like amino acids and lipids were also obtained. CONCLUSIONS: The RFP, powered by flowing water, creates an innovative culture technology for economical cultivation of microalgal cells and production of microalgal metabolites.

Extract of Pleurotus pulmonarius suppresses liver cancer development and progression through inhibition of VEGF-induced PI3K/AKT signaling pathway.

Liver cancer or hepatocellular carcinoma is one of the leading causes of cancer-related deaths. Conventional chemotherapies are limited by the development of drug resistance and various side effects. Because of its non-toxicity and potent biopharmacological activity, metabolites derived from mushrooms have received more attention in cancer therapy. Our previous studies have demonstrated the anticancer effects of polysaccharide-protein complexes derived from the Pleurotus mushrooms. The aim of this study was to investigate the underlying molecular mechanism of the anticancer activity of a hot water extract containing a polysaccharide-protein complex isolated from Pleurotus pulmonarius (PP) in liver cancer cells. Our results indicated that exposure of liver cancer cells to PP not only significantly reduced the in vitro cancer cell proliferation and invasion but also enhanced the drug-sensitivity to the chemotherapeutic drug Cisplatin. Both oral administration and intraperitoneal injection of PP significantly inhibited the tumor growth in xenograft BALB/c nude mice. PP triggered a marked suppression of the PI3K/AKT signaling pathway in liver cancer cells in vitro and in vivo, and overexpression of the constitutively active form of AKT, Myr-AKT, abrogated this effect and the inhibited proliferation and invasion by PP. Both western blot and ELISA results showed that PP-treated liver cancer cells had reduced expression and secretion of vascular endothelial growth factor (VEGF). Addition of recombinant human VEGF attenuated the inhibitory effects of PP on PI3K/AKT pathway and the cancer phenotypes. Our results demonstrated that PP suppressed the proliferation, invasion, and drug-resistance of liver cancer cells in vitro and in vivo, mediated by the inhibition of autocrine VEGF-induced PI3K/AKT signaling pathway. This study suggests the potential therapeutic implication of PP in the treatment of human liver cancer.

Enhancement of polyunsaturated fatty acids and total carotenoid production in microalgae by ultraviolet band A (UVA, 365 nm) radiation.

Two microalgae, Porphyridium cruentum and Platymonas subcordiformis , were subjected to a 3-day exposure of ultraviolet band A (UVA) radiation at 365 nm (∼1.32-1.35 W/m(2)) and photosynthetically active radiation (PAR) (∼11.56-11.62 W/m(2)) followed by a 3-day UVA-free (exposure to PAR only) treatment. UVA inhibited the growth of P. subcordiformis and P. cruentum during the UVA-exposure period. Significant increases (p < 0.05) of total polyunsaturated fatty acids (PUFAs), saturated fatty acids (SFAs), and lipid content were found in P. cruentum during the UVA exposure period, whereas such increases in P. subcordiformis were observed only at the end of the UVA-free period. Concentrations of individual PUFAs including linoleic acid, eicosatrienoic acid, and eicosapentaenoic acid as well as total carotenoids were significantly increased (p < 0.05) at different stages of the UVA treatment in both microalgae. UVA (365 nm) radiation has the potential application for producing microalgal biomass rich in PUFAs and carotenoids as a natural functional ingredient.

+UVA treatment increases the degree of unsaturation in microalgal fatty acids and total carotenoid content in Nitzschia closterium (Bacillariophyceae) and Isochrysis zhangjiangensis (Chrysophyceae).

The production of metabolites by microalgae is affected by environmental conditions in which they are living. The metabolic responses of two marine microalgae, Nitzschia closterium and Isochrysis zhangjiangensis, to a 3-day UVA-stress and 3-day UVA-recovery treatment were compared, based on their growth, fatty acid profiles and content of total carotenoids. When cultured under photosynthetically active radiation, coupled with UVA treatment, both microalgae underwent a significant increase in their growth during the UVA-recovery period compared to the control. The proportions of polyunsaturated fatty acids, including linoleic acid and eicosapentaenoic acid, as well as total carotenoids, were significantly increased in both microalgae, mainly in the UVA-stress period, but not the UVA-recovery period. The metabolic responses of the two microalgae to UVA treatment were species-dependent and could be utilised to produce microalgal biomass rich in polyunsaturated fatty acids and carotenoids for use as functional food ingredients.